Wagner ProCoat Max Bedienungsanleitung

Español Français EnglishOwner’s ManualRead this manual for complete instructions0811 • Form No. 0504603BContents 2 Important Safety Information 4

English 10 4. Practice SprayingStartYou will need: • Scrap material / cardboardNotes:If the spray pattern becomes distorted or stops completely whi

English 11 Spray Pattern Overlap Your StrokesSpray Technique8” - 10”(20 - 25 cm)!GOOD SPRAY PATTERN BAD SPRAY PATTERN: TAILINGCORRECTSee page 12-14St

English 12 Spraying Troubleshooting -Clear the Spray TipStartYou will need: • Scrap material / cardboardDo not attempt to unclog or clean the tip w

English 13 Spraying Troubleshooting -Clean the Spray Gun FilterStartYou will need: • Wrench • Warm, soapy water for latex material • Mineral sp

English 14 Spraying Troubleshooting -Clean the Inlet FilterStartYou will need: • Warm, soapy water for latex material • Mineral spirits for oil b

English 15 Short Term StorageStartEnglishYou will need: • Water • Plastic bag or bucket • Rags • Stir stickThis procedure should be used when

Follow these steps if you used latex materials AND if you have a garden hose available. If you do not have a garden hose available, follow the Cleanu

English 17 5. Remove the inlet lter from the suction tube and place it into waste container. 6. Thread pump cleaning adapter onto garden hose.

English 18 Cleanup - Oil-Based MaterialsStartYou will need: • Mineral spirits if using oil-based material • Warm, soapy water if using latex mate

English 19 Cleaning the Spray Gun ComponentsStartYou will need: • Soft bristled brush • Multi-Purpose Oil • Warm, soapy water if using latex ma

English 2 SafetySafetyImportant Safety InformationRead all safety information before operating the equipment. Save these instructionsIndicates a haza

English 20 Long Term StorageStartYou will need: • Multi-Purpose Oil • RagsIMPORTANT: Store the unit indoors with the power cord wrapped around t

English 21 Replacement of the outlet valve may be necessary if spray performance remains poor after following steps in the Fix Spraying Problems sect

English 22 TroubleshootingBefore servicing, always release system pressure by following Pressure Relief Procedure (page 7).Problem A: The sprayer doe

English 23 Problem E: The spray gun leaksCause Solution1. Gun lter housing is loose Tighten handle2. Internal parts of spray gun are worn or dirty T

English Français Español 72167324598Sprayer • Pulvérisateur • Rociador Parts List • Liste de Pièces • Lista de Piezas

EnglishEspañolFrançaisEspañol 73Item Article ArticuloPart No. No de piéce Pieza No. English - Description Français - Description Español - Descripci

English Français Español 74Parts List • Liste de Pièces • Lista de piezas1456327Spray Gun • Pistolet • PistolaItem Article ArticuloPart No. No de pié

EnglishEspañolFrançaisEspañol 75Tip/Filter Accessories • Accessoires de buse/ltre • Accesorios de punta/ltroEnglish - All spray tips and filters lis

English Français Español 76Limited WarrantyAIRLESS PAINT SPRAY EQUIPMENT This product, manufactured by Wagner Spray Tech Corporation (Wagner), is war

English 3 8. Check hoses and parts for signs of damage, a leak can inject material into the skin. Inspect hose before each use. Replace any damag

SprayguardSpray tipSaddle seat**Washer**Saddle seat and washer come pre-assembled inside spray guard**Cartbutton (2)CartON / OFFswitchClipPump cleanin

English 5 Proper use and functionsStartControls and FunctionsON/OFF switch:The ON/OFF switch turns power to sprayer on and off. (O=OFF, |=ON)PRIME/SP

English 6 1. AssemblyStart 1. To extend the cart handle, push the two cart buttons and pull the handle out until it locks into place. 2. Threa

English 7 Pressure Relief Procedure**Perform when instructedStartImportant Safety WarningBe sure to follow the Pressure Relief Procedure when shuttin

English 8 2. Load MaterialStart 1. Push the red inlet release button to ensure proper inlet valve operation. 4. Hold return tube over waste bucke

English 9 3. Getting Material to FlowStartYou will need: • Scrap material / cardboard • Drop cloths to protect oors and furnishings from overspr